features: compact 240w with 1u height power density: 10.41 watts/cu in rd edition 120w ~ 240w ac - dc pfc medical switching power supply prl1103d dual output series input voltage: 90 ~ 264vac full range, 47 ~ 63hz. input current: 5a at 90vac. inrush current: max. 70a@230vac & 35a@115vac; cold start. power factor correction: pf>0.95 typical. transient response: returns to within 1% in less than 2.5ms for a 50% load change and the peak transient does not excess 5%. overshoot: turn - on & off overshoot 5% over nominal voltage. efficiency: 75% ~ 87% depends on model. turn on delay : 1 second maximum at 230 vac. hold up time: 16ms min. at 80% of full load. adjustability : output user adjustable +/ - 5% minimum. fan drive: 12vdc/300ma offering to drive an external fan. fan fail (ff) alarm: designated as ff on pin 3 of cn3 is a open collector output rated for 28vdc/5ma sink current maximum, it will go high when a fan failure is detected. remote on - off: designated as inh on pin4 of cn3, requires a low signal to inhibit output. power supply on: green led designated as led1 on the pcb. power good: pg on cn3 goes high 100 - 500ms after dc regulation and low at least 1ms before loss of regulation (open collector). input fusing protection: dual t5a/250v fuses inserted in primary. over - power protection: 110~140% of i - max; auto - recovery. short circuit protection: trip without damage and auto - recovery. over voltage protection: unit latching down when output exceed 130% and recycle ac input to reset. over - temperature protection: unit protected of excessive operating ambient 110 and automatic recovery. switching frequency: pfc 50k~70k hz; pwm 45k~55k hz. storage temperature : - 20 to 85 . operating temperature : 0 to 70 ambient, de - rating at 2.5% per degree from 50 to 70 . operating humidity : 5% to 90% rh, non - condensing. storage humidity: 5% to 95% rh, non - condensing. emc: en60601 - 1 - 2 class b conducted / radiated; en61000 - 3 - 2,3; iec61000 - 4 - 2, 3, 4, 5, 6, 8, 11. safety regulation: en/ iec/ ul60601 - 1 3 rd edition. vibration: 5 ~ 50 hz, acceleration 7.35 m/s*s on x,y and z axis. leakage current: < 300ua @ 264vac. hi - pot test : 1500 vac input line to chassis (10ma dc cut off current); isolating 4000vac primary to secondary windings; primary to core 1500vac. all for 3 sec. grounding test: apply 25 a from ground pin of the three prong plug to the far most earth. max allowable resistance 0.1 ohm. mtbf: 100000 hrs (according to mil - hbk - 217f) at 30 . cooling: u type: u - chassis @240w max. with 25cfm airflow or 120w max. under air convection. f type: u - chassis with top built - in fan @240w max. e type: enclosed with a built - in fan in the input end @240w max. burn in: 45 +/ - 5 degree c for 1 hour @230vac with full load. enclosure : u type: 5(l) x 3.2(w) x 1.5(h) inches. f type: 5(l) x 3.2(w) x 2(h)inches. e type: 3.2(l) x 6.5(w) x 1.6(h)inches weight : maximum u - type weight is 500g. warranty: 2 years. copy right ultra level tech co., ltd 2015, all right reserved. specifications subject to change without notice. product specifications: e type (enclosed with end built - in fan): 3.2(w) x 6.5(l) x 1.6(h) inches u type (u - chassis only): 3 .2 ( w ) x 5 ( l ) x 1.5 ( h ) inches. f type (u - chassis with top built - in fan ): 3.2 ( w ) x 5 ( l ) x 2( h ) inches. ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465 cb
output voltage / current rating chart: measured at output power connector. note: * prl1103d series are designated as prl1103dx - y where x can be u (u - chassis only), f (u - chassis with top cover and fan installed) or e (enclosed type with rear side built - in fan) , y can be 0512, 1224 . * u type: u - chassis @240w max. with min. 25cfm forced airflow or 120w max. under air convection. * e type: enclosed with rear side built - in fan @240w max. * f type: u - chassis with top built - in fan @240w max. * ripple and noise is measured from 10khz to 20mhz bandwidth at output with parallel 0.1f ceramic and 22f electrolytic capa cit ors. * 10% minimum load is required to maintain the ripple and regulation. * output is fully isolated. input connector (cn1): u and f type: mating jst part no. vhr - 5n or equivalent (5pin, 3 used), or terminal block: howder m3 screws 3 pin 6.35mm center p art no. hd - 601 - 3p; pcb labeling: l=line; n=neutral; g=chassis ground . e type: iec320 snap - in mounting type or terminal block: howder hd - 602 - 3p. output connector (cn2): mating jst part no. vhr - 8n terminal block C howder m3 part no. hd - 816 - 3p output pin assignment: (see table in right). mounting inserts: 6 places m3x0.7. maximum penetration 4mm sees outline drawing for location. logic signal connector (cn3) : mating jst xhp - 4 or equivalent (chyao shiunn js - 2001 - 04); mating pins: jst sxh - 002t - p0.6 for awg 30 to 26. : fan driver connector (fan1) : mating connector is jst p/n xhp - 3 (3 pins 0.98 pitch) or equivalent (chyao shiunn js - 2001 - 03). howder molex v1 : pin 3 v1 : pin 6~8 rtn : pin 2 rtn : pin 2~5 v2 : pin 1 v2 : pin 1 copy right ultra level tech co., ltd 2015, all right reserved. specifications subject to change without notice. outline drawing: model number output voltage max. output current regulation ripple & noise type u (force air) & e & f type u (convection) prl1103dx - 0512 v1:+ 5v 24a 12a +/ - 5% 1% v2:+ 12v 13.33a 6.67a +/ - 5% 1% prl1103dx - 1224 v1:+ 12v 13.33a 6.67a +/ - 5% 1% v2:+ 24v 6.67a 3.33a +/ - 5% 1% ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465
copy right ultra level tech co., ltd 2015, all right reserved. specifications subject to change without notice. u type (u - chassis only): 5 (l) x 3.2(w) x 1.5(h) inches; weight: 500g. e type (enclosed with rear side built - in fan): 6.5 (l) x 3.2(w) x 1.6(h)inches; weight: 650g. ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465 81.28 [3.20] 165.10 [6.50] 114.30 [4.50] 6.35 [0.25] 68.58 [2.70] 44.52 [1.75] 64.77 [2.55] 8.26 [0.32] 19.05 [0.75] 40.64 [1.60]
copy right ultra level tech co., ltd 2015, all right reserved. specifications subject to change without notice. f type (u - chassis with top built - in fan): 5 (l) x 3.2(w) x 2(h) inches; weight: 600g. ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465
|